Old Roof Decking

That will save you as much as 1 000 and a fair bit of mess but it means the roofer can t inspect and repair the decking and flashing underneath.

Old roof decking.

In the 1950s plywood sheathing and particleboard became common and today most standard construction roofs use either half inch plywood or particleboard s big brother oriented strand board osb. These decks rarely had roof insulation installed on them since energy was relatively cheap so typical construction might have called for a layer of rosin treated paper followed by two layers of bitumen impregnated roofing felt nailed followed by three more layers of 15 asphalt or pitch impregnated organic roofing felt mopped together. It s important to know what kind of a substrate is underneath the wood shakes before removing. Prevent future mold growth.

Plywooding over old roof deck one thing to consider when stripping off the old plywood is to remove and replace as you go. Older homes may very well have a different type of roof decking than newer structures. Plank sheathing usually 1 6 or 1 8 was used as a roof deck before plywood. It is important for us to point this out because here in maine many historic homes are maintained for both residential and business uses.

Since the boards used for shiplap were manufactured here in the pacific northwest it was still cheaper than plywood up through the 1960s. Until the 1940s exterior grade plywood was not available. As long as the new plywood itself can span the distance and carry the roof wind seismic and snow loads for your region adding new ply over old is just fine. Old houses with asphalt shingles usually had either tongue and groove boards or straight sided boards abutting.

In the first half of the 20th century roofs in missouri were built with wood shingles over planks spaced about 1 apart. Strip away the old you re permitted to have two layers of asphalt shingles on your roof so if there s only one in place now you can have a new layer installed right on top. The new plywood thickness should be. To prevent future mold growth remove the source of moisture causing it.

We knew that this old house had significant gaps in the wood p. In older houses decking is typically made of lumber place perpendicular to rafters trusses.